霍林郭勒褐煤NaOCl氧化残渣的分离与分析Separation and Analysis of Oxidation Residue Obtained from Huolinguole Lignite in NaOCl
宫贵贞;储济明;魏贤勇;宗志敏;
GONG Guizhen;CHU Jiming;WEI Xianyong;ZONG Zhimin;Xuzhou Institute of Technology;Key Laboratory of Coal Processing and Efficient Utilization, China University of Mining and Technology;Engineering Research Center of Xuzhou Environmental Protection Coating Material;
摘要(Abstract):
依次用石油醚、CS2、丙酮和甲醇4种溶剂通过索式萃取对霍林郭勒褐煤(HL)的次氯酸钠(NaOCl)水溶液氧化残渣进行分级萃取.发现总的萃取率大于原煤萃取率.所得各级萃取物用GC/MS分析检测,E1和E2馏分中分别检测到85种和23种化合物,E3和E4萃取馏分中无GC/MS可检物质.结果表明煤的次氯酸钠氧化有助于提高煤的萃取率,索式萃取可实现氧化残渣的族组分分离.
Oxidation residue obtained from Huolinguole(HL)lignite in aqueous sodium hypochlorite(NaOCl),was subjected to sequentially fractional extraction with petroleum ether,CS2,acetone and methanol by Soxhlet extraction.The total extraction yield was greater than that of the raw coal.The extracts were analysed with GC/MS.85and 23compounds were founded in E1 and E2 fractions,respectively,There is no compound detected from E3 and E4.The results show that oxidation of coal with NaOCl will help to improve the yield of coal extraction,and oxidation residues can be effectively separated to family components by Soxhlet extraction.
关键词(KeyWords):
氧化残渣;分离;GC/MS分析
oxidation residue;separation;GC/MS analysis
基金项目(Foundation): 国家自然科学基金重点项目(20936007);国家自然科学基金面上项目(50974121);国家自然科学基金委员会创新研究群体科学基金资助项目(50921002);; 徐州工程学院培育项目(XKY2011103)
作者(Authors):
宫贵贞;储济明;魏贤勇;宗志敏;
GONG Guizhen;CHU Jiming;WEI Xianyong;ZONG Zhimin;Xuzhou Institute of Technology;Key Laboratory of Coal Processing and Efficient Utilization, China University of Mining and Technology;Engineering Research Center of Xuzhou Environmental Protection Coating Material;
DOI: 10.16366/j.cnki.1000-2367.2013.05.013
参考文献(References):
- [1]Oshika T,Okuwaki A.Formation of aromatic carboxylic acids from coal-tar pitch by two-step oxidation with oxygen in water and in alkaline solution[J].Fuel,1994,73(1):77-81.
- [2]Hayashi J I,Matsuo Y,Kusakabe K,et al.Depolymerization of lower rank coals by low-temperature O oxidation[J].Energy Fuels,1997,11(1):227-235.
- [3]Hayashi J I,Aizawa S,Kumagai H,et al.Evaluation of macromolecular structure of a brown coal by means of oxidative degradation in aqueous phase[J].Energy Fuels,1999,13(1):69-76.
- [4]Bergh J J,CronjéI J,Dekker J,et al.Non-catalytic oxidation of water-slurried coal with oxygen:identification of fulvic acids and acute toxicity[J].Fuel,1997,76(2):149-154.
- [5]Yürüm Y,Altuntas N.Air oxidation of Beypazari lignite at 50℃,100℃and 150℃[J].Fuel,1998,77(15):1809-1814.
- [6]Zhumanova M,Usanboev N,Namazov S,et al.Oxidation of brown coal of Angren deposit with a mixture of nitric and sulfuric acids[J].Russ J Appl Chem,2009,82(12):2223-2229.
- [7]Alvarez R,Clemente C,Gómez-Limón D.The influence of nitric acid oxidation of low rank coal and its impact on coal structure[J].Fuel,2003,82(15-17):2007-2015.
- [8]Mae K,Shindo H,Miura K.A New two-step oxidative degradation method for producing valuable chemicals from low rank coals under mild conditions[J].Energy Fuels,2001,15(3):611-617.
- [9]Liu Z X,Liu Z C,Zong Z M,et al.GC/MS analysis of water-soluble products from the mild oxidation of Longkou brown coal with H2 O2[J].Energy Fuels,2003,17(2):424-426.
- [10]Huang Y G,Zong Z M,Yao Z S,et al.Ruthenium ion-catalyzed oxidation of Shenfu coal and its residues[J].Energy Fuels,2008,22(3):1799-1806.
- [11]Kidena K,Tani Y,Murata S,et al.Quantitative elucidation of bridge bonds and side chains in brown coals[J].Fuel,2004,83(11-12):1697-1702.
- [12]宫贵贞,魏贤勇,王双丽,等.东滩烟煤在NaOCl水溶液中的氧化解聚[J].中国矿业大学学报,2011,40(4):603-607.
- [13]宫贵贞,魏贤勇,宗志敏.两种煤的次氯酸钠水溶液降解产物的分离与分析[J].燃料化学学报.2012,40(1):1-7.
- [14]Yao Z S,Wei X Y,Lv J,et al.Oxidation of Shenfu coal with RuO4 and NaOCl[J].Energy Fuels,2010,24(3):1801–1808.
- [15]宫贵贞,魏贤勇,姚子硕,等.霍林郭勒褐煤在NaOCl水溶液中的氧化反应[J].武汉科技大学学报,2010,33(1):66-70.
- [16]周建石,魏贤勇,李鹏,等.高温煤焦油中杂环化合物的分析与分离[J].河南师范大学学报:自然科学版,2011,39(5):77-80.
- [17]姚婷,宗志敏,宫贵贞,等.一种改质煤焦油的组分分析[J].河南师范大学学报:自然科学版,2011,39(6):73-77.
- [18]岳晓明,王英华,魏贤勇,等.微波辅助下锡林浩特褐煤的CS2-丙酮萃取物组成分析[J].河南师范大学学报:自然科学版,2012,40(2):91-96.
- [19]王晓华.煤的溶剂分级萃取研究[D].徐州:中国矿业大学,2002.
- 宫贵贞
- 储济明
- 魏贤勇
- 宗志敏
GONG Guizhen- CHU Jiming
- WEI Xianyong
- ZONG Zhimin
- Xuzhou Institute of Technology
- Key Laboratory of Coal Processing and Efficient Utilization
- China University of Mining and Technology
- Engineering Research Center of Xuzhou Environmental Protection Coating Material
- 宫贵贞
- 储济明
- 魏贤勇
- 宗志敏
GONG Guizhen- CHU Jiming
- WEI Xianyong
- ZONG Zhimin
- Xuzhou Institute of Technology
- Key Laboratory of Coal Processing and Efficient Utilization
- China University of Mining and Technology
- Engineering Research Center of Xuzhou Environmental Protection Coating Material